Method of producing improved lithopone

What’s recently changed with titanium dioxide and regulations?

The skin of an adult person is, in most places, covered with a relatively thick (∼10 μm) barrier of keratinised dead cells. One of the main questions is still whether TiO₂ NPs are able to penetrate into the deeper layers of the skin. The majority of studies suggest that TiO₂ NPs, neither uncoated nor coated (SiO₂, Al₂O₃ and SiO₂/Al₂O₃) of different crystalline structures, penetrate normal animal or human skin. However, in most of these studies the exposures were short term (up to 48 h); only few long-term or repeated exposure studies have been published. Wu et al.83 have shown that dermal application of nano-TiO₂ of different crystal structures and sizes (4–90 nm) to pig ears for 30 days did not result in penetration of NPs beyond deep epidermis. On the other hand, in the same study the authors reported dermal penetration of TiO₂ NPs with subsequent appearance of lesions in multiple organs in hairless mice, that were dermal exposed to nano-TiO₂ for 60 days. However, the relevance of this study for human exposure is not conclusive because hairless mice skin has abnormal hair follicles, and mice stratum corneum has higher lipid content than human stratum corneum, which may contribute to different penetration. Recently Sadrieh et al. performed a 4 week dermal exposure to three different TiO₂ particles (uncoated submicron-sized, uncoated nano-sized and coated nano-sized) in 5 % sunscreen formulation with minipigs. They found elevated titanium levels in epidermis, dermis and in inguinal lymph nodes, but not in precapsular and submandibular lymph nodes and in liver. With the energy dispersive X-ray spectrometry and transmission electron microscopy (TEM) analysis the authors confirmed presence of few TiO₂ particles in dermis and calculated that uncoated nano-sized TiO₂ particles observed in dermis represented only 0.00008 % of the total applied amount of TiO₂ particles. Based on the same assumptions used by the authors in their calculations it can be calculated that the total number of particles applied was 1.8 × 10¹³ /cm² and of these 1.4 x10⁷/cm² penetrated. The surface area of skin in humans is around 1.8 m²  and for sun protection the cream is applied over whole body, which would mean that 4 week usage of such cream with 5 % TiO₂ would result in penetration of totally 2.6 × 10¹⁰ particles. Although Sadrieh et al.concluded that there was no significant penetration of TiO₂ NPs through intact normal epidermis, the results are not completely confirmative.

Titanium dioxide is the most widely used whitening pigment in the world and has been linked to adverse health effects, particularly genotoxicity and intestinal inflammation. It is applied as food coloring and a whitening agent to a wide variety of foods, including chewing gum, cakes, candies, breads and ice cream. 

So, what does it all mean for you, the consumer? Should you stop eating Skittles or begin checking foods for the presence of titanium dioxide? Here's a closer look.

Among the raw materials for coating production, titanium dioxide is more ideal, followed by lithopone. The covering power of lithopone is only that of titanium dioxide, and the price of lithopone is much lower than that of titanium dioxide, so lithopone still occupies a large market share.

Applications

Amount: if too little titanium dioxide is added, the distance between particles is too large and there is not enough opacity, while if the titanium content is too high, the particles interfere with each other and poor efficiency is obtained.

But that depends on how titanium dioxide is being used and how you might come into contact with it. The International Agency for Research on Cancer (IARC) has classified titanium dioxide as possibly carcinogenic to humans based on studies that showed more lung tumors in rats associated with breathing in titanium dioxide.

There is also some evidence to suggest that exposure to titanium dioxide nanoparticles may be harmful or toxic to the environment, including aquatic life and other organisms. The production and disposal of the mineral may also release pollutants, such as carbon dioxide and sulfur dioxide, into the air and water.

Lithopone factory: Natrosol has some characteristics

Titanium IV oxide is also used in the pharmaceutical industry. It is often used as a coating for medications to improve their stability and appearance. Titanium dioxide helps to protect medications from degradation caused by light, moisture, and other environmental factors. It is commonly used in tablets, capsules, and other oral dosage forms to improve their shelf life and effectiveness.

Relative to a lot of other things that people should be concerned about, titanium dioxide in my mind, is really low on the list. I would be more worried about some substitutes that people are using for titanium dioxide that don't have decades of research associated with it, said Westerhoff.

Understanding Titanium Dioxide